Car steering Volkswagen Passat B3

General information about steering
1 - lid 2 - nut, 50 Nm For vehicles up to 9/93, together with an additional lining washer. 3 - steering wheel 4 — airbag assembly 5 - steering wheel for airbag 6 - Allen bolt...

Steering drive device
Mechanical steering Removal and installation are carried out through the hole in the left wheel arch. Before installation, set the new steering gear to neutral position. 1 - nut,...

Precautions when working with an airbag
The driver's airbag is located in the steering wheel, and the passenger's airbag is located in the instrument cluster on the right. In the event of a severe frontal collision, the...

Removal and installation the airbag assembly
Removal Turn off the ignition, the ignition key in position "0". Disconnect the ground (-) cable from the battery. Caution: This will erase the contents of electronic memory...

Removal and installation the steering wheel
Car without an inflatable airbag Removal Remove the lid with your hands, see chapter " Devices ". Disconnect the electrical wires for the sound signal from the lid. Turn the...

Removal and installation the tie rod end
Note: To replace the steering rods, the steering gear must be removed. Workshop work! Removal Loosen the tie rod end mounting nut. Remove the steering tie rod joint pin from the...

Checking the steering wheel free play
Rack and pinion steering should have no play when turning the steering wheel from lock to lock. Adjustment is performed by two mechanics. Raise the car on the platform. Set the...

Power steering vane pump
A car with a 4-cylinder engine 1 - suction hose 2 - discharge hose 3 - clamp 4 - tension bolt 5 - nut, 20 Nm 6 - front swivel bracket 7 - nut, 20 Nm 8 - tension bracket 9 — bolt,...

Checking the tightness of the steering drive
If there is no oil in the expansion tank, be sure to check the steering for leaks. Start the engine and let it idle. Turn the steering wheel in both directions until it stops and...

Bleeding the steering gear
It is necessary to bleed the air from the steering gear in cases where the lines have been disconnected or when the system is filled with oil again. Attention: Do not use drained...

Elimination of vibrations of the steering wheel / front of the car
Vibration of the steering wheel at a certain speed usually indicates an imbalance of the wheels. Examination Check the tire pressure and adjust if necessary. Perform a test drive....

Steering maintenance
Checking the steering rod joint dust caps Raise the car from the front. Illuminate the protective caps with a lamp and check for damage, paying attention to the presence of traces...

Definition of chassis parameters
Optimum driving dynamics and minimal wear can only be achieved with perfect wheel alignment. In the event of abnormal tyre wear, as well as unsatisfactory driving stability – poor...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Passat B6 Passat B5 Passat B4

Passat B3 Passat B2