Main faults of the lubrication system (VW Golf 4)

CAUSE	METHOD OF ELIMINATION
When the ignition is turned on, the oil pressure indicator light does not come on
The oil pressure sensor is faulty	With the ignition on, disconnect the electrical connector from the oil pressure sensor and connect it to the vehicle ground. If the oil pressure warning light comes on, the oil pressure sensor is faulty and needs to be replaced
Open circuit in the oil pressure sensor electrical circuit or oxidized contacts	Check the electrical circuit of the oil pressure sensor and the condition of the contacts
Oil pressure warning light malfunction	Replace the oil pressure warning light
After starting the engine, the oil pressure warning light does not go out
Engine oil temperature too high	As the engine speed increases, the oil pressure warning light should go out
The oil pressure warning light does not go out when the engine speed increases or lights up while the engine is running
Oil pressure too low	Check the engine oil level and top it up if necessary. Check the oil pressure
Short to ground in the wire from the oil pressure sensor	Disconnect the electrical connector from the oil pressure sensor and isolate it. Turn on the ignition. If the oil pressure warning lamp lights up, check the condition of the electrical circuit of the oil pressure sensor
The oil pressure sensor is faulty	Replace the oil pressure sensor
Low oil pressure at all engine speeds
The engine oil level in the engine is below normal	Bring the engine oil level to the normal level
The mesh filter is dirty or there is a hole in the oil pickup tube	Remove the oil pan and clean the strainer or replace the oil pickup tube
Increased clearance in crankshaft bearings	Check the condition of the crankshaft bearings and replace them if necessary
The oil pump is faulty	Remove the oil pump, check its condition and replace it if necessary
Reduced oil pressure at low engine speeds
The oil pump bypass valve is in a permanently open position	Remove the bypass valve and check its condition
Increased oil pressure at engine speeds over 2,000 rpm
The bypass valve does not open	Remove the bypass valve and check its condition

This article is available at russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

The text has been checked: Kolesnikov Artem

Previous articles
Diagnostics of diesel engine faults
Removal and installation the oil pan
Checking oil pressure and oil pressure sensor
Removal and installation a poly V-belt
Checking the compression in the engine cylinders
Removal and installation the intake manifold of a diesel SDI engine

Next articles

Link to this page in different formats

HTMLTextBB Code

Visitor comments

No comments yet

Golf 5 Golf 4 Golf 3

Golf 2 Golf 2 (petrol) Golf 1 (petrol) Golf 1 (diesel)