Contents: Care ↓ Maintenance ↓ Engine ↓ Transmission, main drive ↓ Front axle and steering ↓ Body ↓ Brakes, tires, wheels ↓ Electrical installation ↓ Every 2 years ↓
Care
Maintenance is performed every 7500 km.
- engine: oil and filter change.
- fuel filter: water removal.
- disc brake system: checking the thickness of the pads.
Maintenance
Maintenance is carried out every 12 months according to points without designation, and every 30,000 km of run according to points "=".
The original text is available on the portal (www.vwmanual.ru)
Engine
- engine: Change oil and oil filter.
- cooling and heating system: check the fluid level and antifreeze concentration. Visually check the radiator for leaks and external contamination.
- exhaust system: check for damage.
- engine: visual inspection for leaks in the oil system.
- idle speed: check, adjust if necessary.
- remove water from the fuel filter.
- v-belts: check the tension and condition of all belts.
- =fuel filter: replace.
- =dry air filter: replace insert.
- = toothed belt: check condition and tension.
- =valve clearance: check, adjust if necessary.
- =exhaust gases: visual inspection for smoke formation (naturally aspirated diesel).
- =compression: check.
Transmission, main drive
- protective shells of hinges: check for leaks and damage.
- automatic transmission: check fluid level, top up if necessary.
- automatic transmission: replace fluid, clean main bath and oil filter screen, replace oil bath seal.
Front axle and steering
- tie rod ends: check clearance and fastening, check protective caps.
- axle joints: check clearance and protective caps.
- steering: check for play, check bellows for leaks and damage.
- = servo control: check the fluid level, top up if necessary.
Body
- lubricate the hinges and stoppers with universal grease.
- clean the sliding door, side wall rail and lubricate the roller conveyor with universal grease.
- =check the floor covering and hollow spaces.
- =seat belts: check for damage.
- =retractable roof: clean gutters.
Brakes, tires, wheels
- brake system: check pipelines, hoses, brake cylinders and joints for leaks and damage.
- brake fluid level: check, top up if necessary.
- disc brakes: check the thickness of the front and rear pads.
- set of tires: check the tread depth and tire pressure, tires (including spare wheel) check for wear and damage.
Electrical installation
- all consumers: check functionality.
- lighting system: check and adjust headlights if necessary.
- signaling installation: check the sound signal, light signaling.
- windscreen wiper: check the rubber tips for wear.
- windshield washer: check operation, check position of sprayers, add water, check headlight washer.
- battery: Check voltage and acid level.
Every 2 years
- brake fluid: replace.
Additionally, at mileage of 120,000, 240,000 km, etc.
- replace the timing belt.
Visitor comments