Vehicle maintenance VW Transporter T3

Checking brake hoses and lines
The hoses must not be twisted, pay attention to the colored lines! When the steering wheel is turned all the way, the hoses should not touch any parts. Check joints and fasteners...

Lubrication of movable joints
Lubrication of door hinges The hinges of the driver's door and the seat next to the driver, as well as the door locks, do not require lubrication; they do not require maintenance....

Lubrication and maintenance of diesel vehicles
Despite all efforts to improve the Volkswagen bus more and more and increase its service life, safety and economy through design and technological measures, regular lubrication...

Lubricants
Depending on the operating conditions, motor oils must meet quite different requirements. Therefore, it is very difficult to determine exactly how operating conditions affect...

Smoke Testing
The check must be carried out at an oil temperature of at least 60 degrees C. Blow out the engine from soot deposits while parked, giving full throttle 5 times. Leave the engine...

Gearbox and final drive oil change
There is no need to replace the hypoid packing for the gearbox and final drive. The filling oil quantity is about 4.5 liters. For lubrication of the gearbox and main gear, hypoid...

Installing a car on trestles
The vehicle may only be lifted using the locations shown in the illustrations, front and rear are the transverse support point. Caution! Never use the crankcase, transmission or...

Maintenance plan (diesel, production up to 8.85)
Care Maintenance is performed 7500 km after the last maintenance, so, at a mileage of 22500, 37500 km, etc. Under difficult operating conditions (mainly short-haul transportation,...

Maintenance plan (diesel, production since 9.85)
Care Maintenance is performed every 7500 km. engine: oil and filter change. fuel filter: water removal. disc brake system: checking the thickness of the pads. Maintenance...

Maintenance plan (petrol, release up to 8.85)
Service Maintenance is carried out every 7500 km, and the following work is provided: Engine: oil change. Brake fluid expansion tank: Checking the fluid level. Brake pads:...

Maintenance plan (petrol, release from 9.85)
Service Maintenance is carried out every 15,000 km, but not less than once a year, and the following work is provided. When operating in severe conditions, such as frequent...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Transporter T4 Transporter T3