Instructions: Before removing units marked ** disconnect the battery. The car has a plate that informs about the type of refrigerant used and the filling volume of the system. Checking with the tester -VAS 5051B- (or the subsequent model).
- 1 - Front panel**
- 2 - Light photosensor "G107" or light photosensor 2 "G134", purpose: regulation of the position of the temperature control flap and fan speed depending on the light level, emergency operation mode in case of failure: the set temperature value is maintained by the Climatronic control unit "J255"
- 3 - Central deflector
- 4 - Deflector
- 5 - Right deflector temperature sensor "G151"
- 6 - Climatronic control unit "J255", Climatronic control unit "J255" and control and display panel of the Climatronic air conditioning system "E87" are a single, non-separable unit.
- 7 - Actuating electric motor of supply ventilation dampers (recirculation) air intake "V425" with a potentiometer for the actuator motor of the supply ventilation/recirculation/air intake flaps "G644"
- 8 - Right air duct for the foot area
- 9 - Supply fan "V2" with supply fan control unit "J126"
- 10- Connector
- 11 - Heat shield
- 12 - Plugs, only for vehicles not equipped with a central air duct
- 13 - Air duct, to remove it you need to dismantle the center console
- 14 - Cabin filter with activated carbon absorber
- 15 - Fitting, depending on the vehicle configuration, for the air duct of the central console; to remove it, it is necessary to dismantle the central console
- 16 - Deflector grilles, depending on the vehicle configuration
- 17 - Air duct to rear passenger footwell, right
- 18 - Air duct to rear passenger footwell, left
- 19 - Evaporator temperature sensor "G308" or evaporator outlet air temperature sensor "G263". Depending on the software version, one of the unit names is displayed on the tester screen. Both units have the same purpose
- 20 - Right temperature control flap actuator "V159"
- 21 - Heating element of additional air heater "Z35", installed only on vehicles with diesel engines not equipped with additional heater
- 22 - Heat exchanger
- 23 - Central flap actuator motor "V70"
- 24 - Left footwell air duct
- 25 - Left temperature control flap actuator "V158"
- 26 - Temperature sensor in the left footwell air duct "G261"
- 27 - Defrost flap actuator motor "V107"
- 28 - Heater and air conditioning module
- 29 - Temperature sensor in the right footwell air duct "G262"
- 30 - Left deflector temperature sensor "G150"
The information is posted on this resource (vwmanual.ru)
Visitor comments