Removal and installation of a steering wheel Attention! Before removing the airbag, turn off the power to the car's on-board network, then wait at least 1 minute. When removing the steering wheel, special care must be taken...
Removal and installation of a multipurpose steering wheel Removing 1. Remove the driver's airbag before removing the steering wheel. Removal and installation of an airbag are described in the chapter «Passive safety system». 2....
Steering column — removal and installation Attention! Welding or straightening of load-bearing or guiding suspension elements is not allowed. Corroded bolts or screws and nuts must be replaced. Removing The steering column...
Removal and installation of steering draft Removing 1. Remove the wheel. 2. Clean the steering gear in the area of the tie rod boot. 3. Separate crimp and spring collars of an anther of steering draft and move it back. 4....
Hydraulic Power Steering — Design Description 1. Cardan joint 2. Bolt: 20 Nm + 90° (bolt must be replaced after each disassembly) 3. Hydraulic hoses 4. Steering gear 5. Knuckle 6. Nut: 20 Nm + 90° 7. Subframe with console 8....
Removing air from the steering system Check the hydraulic oil level and top up if necessary. Raise the vehicle until the front wheels are completely unloaded. Briefly start the engine (for a maximum of 2 seconds)....
Steering gear repair Check tip dusters (1, 15) tie rods for damage. After removing and installing the tie rod ends, it is necessary to adjust the wheel alignment angles. Check the anthers (5) steering...
Power Steering Rotary Pump When the working fluid decreases from the tank, it is usually necessary to check the tightness of the system. In the event of leaks in the pipe connection area, the lines and...
Steering gear with electromechanical booster Removing 1. After opening the locks, remove the floor lining in the driver's footwell. 2. Remove the universal joint from the steering shaft. 3. Remove the front wheels. 4. Turn...
Tightening torques for threaded fasteners of steering parts Steering column Connected nodes and parts Threaded connection Torque support bracket M8x30 20 Nm Support bracket to body M8x30 20 Nm Support bracket to support bracket М8х94 20 Nm...